GPS & Electronics
Fishing
Covers, Seats & Biminis
TV, Audio & Video
Cameras
Apparel & Footwear
Watersports
Binoculars & Telescopes
Safety
Navigation & Communication
Cabin, Galley & Housewares
Anchors & Dock
Motor & Engine
Electrical & Plumbing
Maintenance
Gifts
FURUNO | GARMIN | HUMMINBIRD | ICOM | LOWRANCE | NORTHSTAR | OKUMA | PENN | RAYMARINE | SHAKESPEARE | UNIDEN
How to Fight Corrosion Aboard Your Boat!
Article Index Go to Article Index Bookmark this Page Bookmark This Page E-Mail This Article to a Friend

HOW TO FIGHT CORROSION ABOARD YOUR BOAT
by Ron Ballanti

If you use your boat in saltwater, there’s one problem you can count on – corrosion. The corrosive effects of salt water and sea air can pit and destroy your on-deck hardware, turn moving parts into stationary ones, and wreak havoc on your wiring and marine electronics.

This doesn’t mean, however, that boaters are powerless against the effects of corrosion. The key is vigilance. You need to develop a regular routine of maintenance and preventative measures and stick to them over the long run.

The most basic step is to thoroughly wash your boat after every trip. Simply spraying your boat down with fresh water is not enough. You need to sponge off everything with a mild soap – dishwashing liquid or Simple Green are good – and then rinse well. Don’t spray water directly onto exposed electronics like fishfinders and nav aids. Wipe these off with a clean, slightly damp cloth and treat them with a corrosion inhibitor (we’ll discuss these later).

Corrosion will attack any metal – even stainless. When it does, it’s like a cancer. Left untreated, it will spread to other places and cause serious damage. So it’s important to treat or remove minor corrosion problems while they are still small.

If possible, replace any heavily corroded hardware such as cleats or hinges. Pay close attention to the mounting screw on railings, grab rails, hatches and any deck hardware. If you see rusty stains on these, it’s a sign that salt water has seeped between the screw and fiberglass or wood and hidden corrosion may be forming under the deck, bulkhead or gunwale.

When you replace any hardware, it’s important to properly seal the bolts or screws with marine bedding compound to prevent this problem from recurring.

Scratches in stainless or aluminum railings can allow corrosion to get a foothold, so it’s important to treat these right away (a tip – don’t clean rails and T-tops with steel wool; it causes small scratches which can rust over time). If you do see a scratch in stainless, smooth it out with fine grit (#600) sandpaper and buff it out with metal polish.

If there are scratches on your outboard motor or outdrive, immediately touch these up with paint from the manufacturer. In addition, check the sacrificial zinc anodes. These anodes (which should be bonded to the engine by contact or bonding wires) are made of zinc and “sacrifice themselves to the effects of galvanic corrosion, thus protecting the lower unit or outdrive. As they do their job, they rot away, so it’s important to check them frequently. If they are more than 50 percent gone, replace them with new ones.

Proper grounding of your electronics systems can also prevent galvanic corrosion. Don’t attempt to take a short cut by running a ground wire to a through-hull fitting. Mount a grounding shoe. Even the smallest amount of stray voltage through the ground wire can cause rapid galvanic corrosion. I learned this from experience. Fortunately, the price of the lesson was only a dead bait pump. It could have been much worse.

Another potential corrosion trouble spot is wherever two dissimilar metals meet. For example, corrosion will form where stainless screws are set in aluminum. Treating both metals with a product called Tef-Gel will keep this from happening.

It’s also very important to check all wiring periodically for any nicks in the insulation. Replace any damaged section immediately. Pell back the insulation until you’re sure you’ve found all the corrosion (you may need to replace an entire wire). Using marine-wire-grade wire of the same gauge, repair or replace the damaged section. Use marine connectors and coat all connections with liquid electrical tape for extra protection.

Fortunately, several advanced products have recently been developed to help boaters treat and prevent corrosion. They work very well, and should be applied regularly to just about any surface – T-tops, hardware, engines, electronics, wiring – you name it. Some of the most popular are Corrosion-X and Boeshield T-9. Boeshield T-9, which was developed by the Boeing Aircraft Corporation to protect jet aircraft, works in an unusual way. It leaves an invisible, durable wax coating to prevent rust from forming. Boeshield also offers a phosphoric acid-based corrosion “pre-treatment”, called Rust Free, which can safely remove surface rust and rust stains from all metals, fiberglass and fabrics.

You can never completely eliminate corrosion on your boat. However, if you regularly inspect your vessel (above decks and below) and take the proper maintenance steps, you can keep corrosion under control. It may be hard work, but doing so will help protect your investment and ensure trouble-free days on the water for you and your boat.

About the Author: Ron Ballanti is a veteran outdoor writer, boater and angler. He also owns and operates Strike Zone Communications, a marine public relations and marketing agency based in Northridge, California (Phone: (818) 349-4608. Fax: (818) 709-5524. e-mail: strikezne@earthlink.net).